The Mighty Pen™ Adhesive Remover

1. Identification

Product Identifiers

Product Name

The Mighty Pen Adhesive Remover

Other Names

ECG Label and Adhesive Remover Pen

Product Number(s)

71827-01, 71827-06, EMS71827-01, EMS71827-06

CAS Number

Not available.

Recommended use of the chemical and restriction on use

Company Details

Emergency Contact Details

2. Hazards Identification

Classification of the substance or mixture

Label Elements

Signal Words

None

Hazard Statement(s)

• Hazard-determining components of labelling:
• Naphtha (petroleum), hydrotreated heavy
• ®-P-mentha-1,8-diene
• Flammable liquid and vapour.
• Causes skin irritation.
• May cause an allergic skin reaction.
• May cause genetic defects.
• May cause cancer.
• May be fatal if swallowed and enters airways.

Precautionary Statement(s)

• Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking.
• Use explosion-proof electrical/ventilating/lighting equipment.
• Avoid breathing dust/fume/gas/mist/vapours/spray.
• Wear protective gloves/eye protection/face protection.
• Wear protective gloves.
• Ground/bond container and receiving equipment.
• Keep container tightly closed.
• Use only non-sparking tools.
• Take precautionary measures against static discharge.
• Wash thoroughly after handling.
• Contaminated work clothing should not be allowed out of the workplace.
• Obtain special instructions before use.
• Do not handle until all safety precautions have been read and understood.

Primary route(s) of entry

Human Health

Inhalation

If exposed or concerned: Get medical advice/attention.

Ingestion

Immediately call a POISON CENTER/doctor. Do NOT induce vomiting.

Eyes

If exposed or concerned: Get medical advice/attention.

Skin

(Or hair) Take off immediately all contaminated clothing. Rinse skin with water/shower. Wash contaminated clothing before reuse. If skin irritation or rash occurs: Get medical advice/attention.

Environment

3. Composition / Information on Ingredients

4. First Aid Measures

Ingestion

If symptoms persist consult doctor.

Inhalation

• Supply fresh air and to be sure call for a doctor.
• In case of unconsciousness place patient stably in side position for transportation.

Skin Contact

Immediately wash with water and soap and rinse thoroughly.

Eye Contact

Rinse opened eye for several minutes under running water.

Other Information

No further relevant information available.

5. Firefighting Measures

Suitable extinguishing equipment

Fire

CO₂, sand, extinguishing powder. Do not use water.

HAZCHEM

For safety reasons unsuitable extinguishing agents: Water with full jet.

Special protective equipment and precautions for fire fighters

6. Accidental Release Measures

Personal precautions, protective equipment and emergency procedures

Wear protective equipment. Keep unprotected persons away.

Environmental precautions

No special measures required.

Methods and materials for containment and clean up

• Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
• Dispose contaminated material as waste according to item 13.
• Ensure adequate ventilation.
• Do not flush with water or aqueous cleansing agents.

7. Handling and Storage

Precautions for safe handling

• Ensure good ventilation/exhaustion at the workplace.
• Open and handle receptacle with care.
• Prevent formation of aerosols.
• Keep ignition sources away - Do not smoke.
• Protect from heat.
• Protect against electrostatic charges.
• Keep respiratory protective device available.

Conditions for safe storage

• Keep container tightly sealed.
• Protect from heat and direct sunlight.

8. Exposure Controls / Personal Protection

Exposure Standards

Engineering controls

• Keep away from foodstuffs, beverages and feed.
• Immediately remove all soiled and contaminated clothing.
• Wash hands before breaks and at the end of work.
• Store protective clothing separately.
• Avoid contact with the skin.
• Avoid contact with the eyes and skin.

Personal protective equipment

Eye and face protection

Tightly sealed goggles.

Skin protection

Protective gloves. The glove material has to be impermeable and resistant to the product/ the substance/the preparation. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation. The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed.

Body protection

Not available.

Respiratory protection

In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure use self-contained respiratory protective device.

9. Physical and Chemical Properties

General information

Appearance

Fluid, coloured according to product specification.

Odour

characteristic.

pH

Not determined

Vapour Pressure

2.3hPa

Density

Not determined

Boiling Point

Undetermined

Melting Point

Undetermined

Solubility

Not miscible or difficult to mix.

Specific Gravity of Density

Not available

Flash Point

43°C

Flammable (Explosive) Limits

• Lower: 0.6 Vol%
• Upper: 7.0 Vol%

Ignition Temperature

240°C

Formula

Not available.

10. Stability and Reactivity

Reactivity

Not available.

Chemical stability

No decomposition if used according to specifications.

Possibility of hazardous reactions

No dangerous reactions known.

Conditions to avoid

No further relevant information available.

Incompatible materials

No further relevant information available.

11. Toxicological Information

Acute effects

• 64742-48-9 Naphtha (petroleum), hydrotreated heavy
• Oral LD50 >5000 mg/kg (rat)
• Dermal LD50 >3000 mg/kg (rabbit)
• 5989-27-5 ®-p-mentha-1,8-diene
• Oral LD50 4400 mg/kg (rat)

Eye contact

No irritating effect.

Skin contact

Irritant to skin and mucous membranes. Sensitisation possible through skin contact.

Ingestion

Not available.

Inhalation

Not available.

Toxicity and irritation

• Irritant
• Carcinogenic
• The product can cause inheritable damage.

12. Ecological Information

Ecotoxicity

No further relevant information available.

Persistence and degradability

No further relevant information available.

Bioaccumulative potential

No further relevant information available.

Other adverse effects

Not known to be hazardous to water.

13. Disposal Considerations

General information

14. Transport Information

ADG label required

HAZCHEM

For safety reasons unsuitable extinguishing agents: Water with full jet.

UN Number

UN1993

Proper shipping name

1993 FLAMMABLE LIQUID, N.O.S. (DIPENTENE, naphtha (petroleum), hydrotreated heavy), ENVIRONMENTALLY HAZARDOUS

Transport hazard class

Class 3 Flammable liquids

Packing group

I

Environmental hazard

• Product contains environmentally hazardous substances: ®-p-mentha-1,8-diene
• Marine Pollutant: Yes
• Symbol (fish and tree)

Special precautions for users

• Warning: Flammable liquids
• Danger code (Kemler): 30
• EMS Number: F-E,S-E

Additional information

• Limited quantities (LQ) 0
• Excepted quantities (EQ) Code: E3
• Maximum net quantity per inner packaging: 30mL
• Maximum net quantity per outer packaging: 300mL
• Transport category: I
• Tunnel restriction code: D/E

15. Regulatory Information

Poisons Schedule Number

• None of the ingredients is listed.
• A Chemical Safety Assessment has not been carried out.

Other Information

• Workers are not allowed to be exposed to the hazardous carcinogenic materials contained in this preparation.
• Exceptions can be made by the authorities in certain cases.

16. Other Information

SDS preparation date

24 February 2026

Comments

This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship.