Safety Data Sheets / Technovit 9100 MMA Embedding Kit - Powder New

Safety Data Sheet

Technovit 9100 MMA Embedding Kit - Powder New

Version 1Last reviewed 27 November 2024Catalogue: 14655 (P), EMS14655

1. Identification

Product Identifiers

Product Name: Technovit 9100 MMA Embedding Kit - Powder New
Other Names: Technovit 9100 Powder New
Product Number(s): 14655 (P), EMS14655
CAS Number: Not available.

Recommended use of the chemical and restriction on use

Laboratory chemicals.

Company Details

ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia
(07) 4773 9444
pst@proscitech.com
proscitech.com.au

Emergency Contact Details

ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia
(07) 4773 9444
pst@proscitech.com
proscitech.com.au

2. Hazards Identification

Classification of the substance or mixture

GHS01 GHS02 Exploding bomb, flame.
Self-reactive substances and mixtures - Type B H241 Heating may cause a fire or explosion.
GHS07
Eye Irritation 2A H319 Causes serious eye irritation.
Sensitization - Skin 1 H317 May cause an allergic skin reaction.
Specific Target Organ Toxicity - Single Exposure 3 H335 May cause respiratory irritation.

Label Elements

Signal Words: None
Hazard Statement(s): Hazard-determining components of labelling:
Methyl Methacrylate
dibenzoyl peroxide
Heating may cause a fire or explosion.
Causes serious eye irritation.
May cause an allergic skin reaction.
May cause respiratory irritation.
Precautionary Statement(s): Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
Keep/store away from clothing/combustible materials.
Keep only in original container.
Avoid breathing dust/fume/gas/mist/vapours spray.
Wash thoroughly after handling.
Use only outdoors or in a well-ventilated area.
Contaminated work clothing must not be allowed out of the workplace.
Wear protective gloves/protective clothing/eye protection/face protection.

Primary route(s) of entry

Not available.

Human Health

Inhalation: Remove person to fresh air and keep comfortable for breathing.
Ingestion: No further relevant information available.
Eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Call a poison center/doctor if you feel unwell. If eye irritation persists: Get medical advice/attention.
Skin: Wash with plenty of water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse.

Environment

In case of fire: Use CO₂, powder or water spray to extinguish.
In case of fire: Evacuate area. Fight fire remotely due to risk of explosion.
Store in a well-ventilated place. Keep container tightly closed.
Store in a well-ventilated place. Keep cool.
Store locked up.
Store at temperatures not exceeding 70°F.
Store away from other materials.
Dispose of contents/container in accordance with local/regional/national/international regulations.

3. Composition / Information on Ingredients

Name	CAS No.	Content (w/w)	Classification
Methyl Methacrylate	80-62-6	≤2.5%	Not Available
dibenzoyl peroxide	94-36-0	≤2.5%	Not Available

4. First Aid Measures

Ingestion: If symptoms persist consult doctor.
Inhalation: Supply fresh air and to be sure call for a doctor.
In case of unconsciousness place patient stably in side position for transportation.
Skin Contact: Immediately wash with water and soap and rinse thoroughly.
Eye Contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
Other Information: No further relevant information is available.

5. Firefighting Measures

Suitable extinguishing equipment

Fire: Use fire fighting measures that suit the environment.
HAZCHEM: No further relevant information available.

Special protective equipment and precautions for fire fighters

No special measures required.

6. Accidental Release Measures

Personal precautions, protective equipment and emergency procedures: Not required.
Environmental precautions: Inform respective authorities in case of seepage into water course or sewage system.
Methods and materials for containment and clean up: Ensure adequate ventilation.

7. Handling and Storage

Precautions for safe handling: No special precautions are necessary if used correctly.
Conditions for safe storage: Protect from heat.
Store in a cool location.
Keep receptacle tightly sealed.
Store in cool, dry conditions in well sealed receptacles.
Protect from heat and direct sunlight.

8. Exposure Controls / Personal Protection

Exposure Standards

Material	TWA ppm	TWA mg/m³	STEL ppm	STEL mg/m³
80-62-6 Methyl Methacrylate	100ppm	410mg/m³
94-36-0 dibenzoyl peroxide		5mg/m³

Engineering controls: Keep away from foodstuffs, beverages and feed.
Immediately remove all soiled and contaminated clothing.
Wash hands before breaks and at the end of work.
Avoid contact with the eyes and skin.

Personal protective equipment

Eye and face protection: Tightly sealed goggles.
Skin protection: Protective gloves. The glove material has to be impermeable and resistant to the product/the substance/the preparation. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation. The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed.
Body protection: Protective clothing.
Respiratory protection: In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure use respiratory protective device that is independent of circulating air.

9. Physical and Chemical Properties

General information

Appearance: White powder
Odour: Odourless
pH: Not applicable.
Vapour Pressure: Not applicable.
Density: 1.16g/cm³
Boiling Point: Undetermined.
Melting Point: Undetermined.
Solubility: Insoluble.
Specific Gravity of Density: Not available.
Flash Point: Not applicable.
Flammable (Explosive) Limits: Not determined
Ignition Temperature: Not determined.
Formula: Not available.

10. Stability and Reactivity

Reactivity: No further relevant information available.
Chemical stability: No decomposition if used according to specifications.
Possibility of hazardous reactions: No dangerous reactions known.
Conditions to avoid: No further relevant information available.
Incompatible materials: No further relevant information available.

11. Toxicological Information

Acute effects: No further relevant information available.
Eye contact: Irritating effect.
Skin contact: Irritant to skin and mucous membranes. Sensitisation possible through skin contact.
Ingestion: No further relevant information available.
Inhalation: No further relevant information available.
Toxicity and irritation: Irritant.

12. Ecological Information

Ecotoxicity: Very toxic for fish.
Persistence and degradability: No further relevant information available.
Bioaccumulative potential: No further relevant information available.
Other adverse effects: Not hazardous for water.
Also poisonous for fish and plankton in water bodies.
Very toxic for aquatic organisms.

13. Disposal Considerations

General information

Must not be disposed of together with household garbage. Do not allow product to reach sewage system.
Disposal must be made according to official regulations.

14. Transport Information

ADG label required

HAZCHEM: No further relevant information available.
UN Number: UN3077
Proper shipping name: 3077 ENVIRONMENTALLY HAZARDOUS SUBSTANCE, SOLID, N.O.S.
Transport hazard class: Class 9 Miscellaneous dangerous substances and articles.
Packing group: III
Environmental hazard: Symbol (fish and tree)
Special precautions for users: Warning: Miscellaneous dangerous substances and articles.
Hazard identification number (Kemler Code): 90
EMS Number: F-A,S-F
Stowage Category: A
Stowage Code: SW23 When transported in BK3 bulk container, see 7.6.2.12 and 7.7.3.9
Additional information: DOT
Quantity Limitations:
On passenger aircraft/rail: 400kg
On cargo aircraft only: 400kg
ADR
Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30g
Maximum net quantity per outer packaging: 1000g
IMDG
Limited quantities (LQ) 5kg
Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30g
Maximum net quantity per outer packaging: 1000g

15. Regulatory Information

Poisons Schedule Number: None of the ingredients is listed.
Other Information: A Chemical Safety Assessment has not been carried out.

16. Other Information

SDS preparation date: 27 November 2024
Comments: This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship.